Quantcast
Jump to content

Recommended Posts

Posted

So not only do i have an issue with my suzuki but also a yamaha i got in trade. Basically when you jump the solenoid or push the start button all the starter does is spin. Does not engage motor. I know its not locked up. Guy that i got it from said starter was bad but i dont believe that one bit since it spins when you appmy power. Any ideas?

Posted

Yea, maybe the polarity is backwards. Take the starter off and put your finger on the gear it should turn (in the whole). The starter needs to turn the direction the gear cant be pushed with your finger.  That resistance is the direction the starter should turn to start it. That is if this year bike doesn't jump out to engage like a car starter.

I believe the starter gear should turn right, it does on my yamaha. 

Posted

It  could  be the starter clutch. Its common and happens.   Pull the starter out and bench test it with 12v and see how she spins.  If the gear ⚙️ spins then the starter is fine.    That would leave only the starter clutch of the gear on the starter clutch lost a few teeth.   Shine a flashlight inside the engine and you can see the gear.  Make sure it has teeth. You can also stick your finger inside and try to spin it.  Its should spin free one way and not the other.   If it spins both ways then 100% stater clutch. 

  • Like 1
Posted

So i pulled it apart and the gear that the starter connects to to turn one way bearing keeps coming off the shaft. Is there a way to fix it to stay on the shaft? Can i run a weld on the gear and shaft to lock it in place?

Join the conversation

You can post now and register later. If you have an account, sign in now to post with your account.
Note: Your post will require moderator approval before it will be visible.

Guest
Reply to this topic...

×   Pasted as rich text.   Paste as plain text instead

  Only 75 emoji are allowed.

×   Your link has been automatically embedded.   Display as a link instead

×   Your previous content has been restored.   Clear editor

×   You cannot paste images directly. Upload or insert images from URL.

  • Similar Forum Topics

    • By BuckBilly
      I like to ride in wooded and grassy areas. It takes my mind off the everyday routines and helps me deal with my father's cancer. Also gives me a reason to get involved with forums like this one.
    • By Tinkeringreg
      Hi my name is Greg and I just acquired a free 2000 yamaha kodiac 400 4x4 with the ultramatic transmission that does not run. I plan to get it going and use it around my property

    • By Kaz
      Troubleshooting a no spark issue, was running OK, maybe a little rich, turned it off, now no spark. I've checked/ohmed out the main key switch, the start/stop switch, neutral switch, brake switch - all good. It will crank the starter, but no spark with the starter or when I try the pull start. I've checked all fuses and diodes. Swapped battery. New plug. New coil. Swapped in a used CDI - no help. Traced, removed, cleaned, reattached all grounds. Removed things like my winch from the circuits to be sure a bad relay or something was dragging it down. When testing voltages, the orange wire going from the CDI to the ignition coil shows no/very low voltage-shouldn't it have 12V on it? Sometimes I get a very weak, intermittent glow on my spark tester, but not enough to fire the plug. I've checked continuity on just about all wires in the harness. Checked/cleaned/lubed w dielectric grease- all connections, redid a few that looked old/dirty. I've checked the stator resistances, all good, but have a stator and rectifier ordered anyway, will arrive Sunday. I verified that the rectifier has a voltage output back to charge the battery while cranking - 10.5-11V, low, but expected while starter is engaged. What else can I check as part of troubleshooting? I have a Haines service manual, but the 1999 350 4x4 seems to be an odd model, there isn't an exact electrical diagram for it, but found one for another year that has all the same number of wires and same color wires, so I've referenced that. Any hints, tips or advice would be appreciated! Thanks!
    • By Mhatayas
      What should I do about this , bad oil leak where the filter cover bolts on . Can I use some gasket maker 

    • By Dumass
      My name says it all. I have a '03 Honda Sporttrax 400EX with a new aftermarket carb on it that seems to be having issues. I can start it but it idles really rough and when I give it throttle it just kills the engine. I have tried adjusting the idle screw but to no avail. I am in the San Diego Ca area. 
      Any advice will be greatly appreciated. I would also like to get an owners manual for the thing too but can't seem to find a downloadable one.
×
×
  • Create New...