-
Similar Forum Topics
-
By Thumpinhard25
First thanks for any help guys, new to the forums and it's gotten me this far. I bought a 2001 bear tracker 250 for my family to get around the dirt bikes races. It wasn't running right and had a high idle. Previous owner thought it was a carb problem, so he ordered a new Zoom carb and new intake boot, but it still had the same high idle. ( I believe he had the throttle cable adjusted wrong, because it idled fine when I put it back together) So I tore down and cleaned the stock carb, and it started up and idled fine, but needed to have the choke 1/2 out to run. I swapped to the new zoom carb and had the same issue. Choke half out bike ran ok. I played with the needle and the pilot screw with no change. ( bike did seem to be running rich though, but didn't get better when I tightened pilot screw or raised meddle) I Took it to the races and once I started bouncing around in the cattle fields the quad started cutting out real bad. It would barely run. Sometimes it would run with choke off, sometimes choke 1/2, sometime choke full. I cleaned carb again, checked float level, and boots, no change still wouldn't run. Then suddenly it started running ok again. This makes me believe it's an electrical issue rather then carb. I know there's no air leak, it's been checked, both carbs are clean( I've swapped them out a couple times, it starts up immediately and usually idles fine. But then bogs down/ or stutters under throttle. I saw the post on the guy who disconnected his rectifier and reconnected and suddenly it started working again, which lead me to believe it may be electrical and not carb. So any advice on what I should check? Any way to test the CDI or rectifier? Once again, I appreciate your help.
-
By Ajmboy
So we are almost a month into winter and I've been so busy working on my house that up until today, I didn't realize that we just haven;t gotten any real snow yet to warrant putting the plow on my grizzly. So that got me thinking, what are the latest plows out there and what ATV plows are the best? I've got 2 snow plows for my grizzly, a quadboss pile driver atv plow set up and a snowsport ATV plow. They are both a bit dated now and I tend to stick with the snowsport due to ease of use and I just like it so much. So if you have a plow on your ATV, please let us know what it is and post a picture with your atv/plow would be awesome. Would also like to know what you like and dislike about it.
This is back a while when I did a write up on these 2 plows.... in 2009 I got the snowsport and in 2012 I got the quadboss.
-
By Panupong Pradchaphet
I have a Sportsman 450 HO and almost killed my self when loading it on my truck with ramps. It rolled off the top of the ramps and tailgate and nearly landed on me. I now want to winch the ATV in to the truck. My question is are the front side bed tiedowns in my 2011 RAM strong enough to winch to without distorting the hooks or sides of the bed?
-
By Kaz
Troubleshooting a no spark issue, was running OK, maybe a little rich, turned it off, now no spark. I've checked/ohmed out the main key switch, the start/stop switch, neutral switch, brake switch - all good. It will crank the starter, but no spark with the starter or when I try the pull start. I've checked all fuses and diodes. Swapped battery. New plug. New coil. Swapped in a used CDI - no help. Traced, removed, cleaned, reattached all grounds. Removed things like my winch from the circuits to be sure a bad relay or something was dragging it down. When testing voltages, the orange wire going from the CDI to the ignition coil shows no/very low voltage-shouldn't it have 12V on it? Sometimes I get a very weak, intermittent glow on my spark tester, but not enough to fire the plug. I've checked continuity on just about all wires in the harness. Checked/cleaned/lubed w dielectric grease- all connections, redid a few that looked old/dirty. I've checked the stator resistances, all good, but have a stator and rectifier ordered anyway, will arrive Sunday. I verified that the rectifier has a voltage output back to charge the battery while cranking - 10.5-11V, low, but expected while starter is engaged. What else can I check as part of troubleshooting? I have a Haines service manual, but the 1999 350 4x4 seems to be an odd model, there isn't an exact electrical diagram for it, but found one for another year that has all the same number of wires and same color wires, so I've referenced that. Any hints, tips or advice would be appreciated! Thanks!
-
-
By oxidized_black
these are what i have in my collection ... always looking for more
1985 - 1995 Polaris All Models service manual
1996 - 1998 Polaris All Models service manual
1996 - 2003 Polaris Sportsman & Xplorer 500 service manual
1996 - 2003 Sportsman 400 & 500 ~ Xplorer 500 service manual
1999 - 2000 Polaris All Models service manual
2001 Polaris 90 service manual
2001 Polaris Scrambler 50 ~ 90 Sportsman service manual
2001 Polaris Sportsman 500HO Parts Manual
2001 Polaris Sportsman 500 Parts Manual
2002 - 2003 Polaris Sportsman 600 & 700 Servive Manual
2002 Polaris Sportsman 700 service manual
2003 - 2005 Polaris Magnum 330 service manual
2003 Polaris Predator 500 service manual
2003 Polaris Predator Parts Manual
2003 Polaris Trail Blazer 250 service manual
2003 Polaris Trail Boss 330 service manual Part I
2003 Polaris Trail Boss 330 service manual Part II
2003 Polaris Trail Boss 330 service manual Part III
2004 Polaris Predator 500 Owner's Manual
2004 Polaris Sportsman Owner's Manual
2005 Polaris 400 & 500 Sportsman service manual
2005 Polaris 700EFI Owner's Manual
2005 Polaris 800EFI Owner's Manual
2005 Polaris Sportsman 400 Parts Manual
2005 Polaris Sportsman 500 Parts Manual
2005 Polaris Sportsman 6x6 Owner's Manual
2005 Polaris Sportsman 700EFI & 800EFI service manual
2005 Polaris Sportsman 800 Twin EFI Parts Manual
2006 - 2007 Polaris Outlaw 500 service manual
2007 Polaris 700 800 800x2 EFI service manual
2007 Polaris Ranger 700EFI 6x6 Parts Manual2007 Polaris Ranger 700 4x4 & 6x6 service manual
2007 Polaris Ranger XP 4x4 service manual
2007 Polaris Sportsman 450 & 500EFI - 500X2EFI service manual
2007 Polaris Sportsman 700 800 - 800EFI service manual
2008 Polaris Sportsman 500EFI & 500x2 service manual
2008 Polaris Ranger 6x6 700EFI Parts Manual
2008 Polaris 800 RZR service manual
2008 Polaris Sportsman 700x2 - 800EFI - 800 Touring service manual
2009 Polaris 850HD EPS service manual
2009 Polaris Outlaw 450 & 525 service manual
2009 Polaris Outlaw 90 service manual
2009 Polaris Predator 50 service manual
2009 Polaris Ranger 2x4 service manual
2009 Polaris Ranger 4x4 Crew service manual
2009 Polaris Ranger 500 2x4 service manual
2009 Polaris Ranger 500EFI 4x4 service manual
2009 Polaris Ranger 500EFI 4x4 service manual
2009 Polaris Ranger 700 4x4 Crew service manual
2009 Polaris Ranger 700 4x4 service manual
2009 Polaris Ranger INTL service manual
2009 Polaris Ranger RZR 170 service manual
2009 Polaris Scramber 500 service manual
2009 Polaris Sportsman 300 & 400HO service manual
2009 Polaris Sportsman 450 & 500X2 service manual
2009 Polaris Sportsman 500 service manual
2009 Polaris Sportsman 6x6 800 service manual
2009 Polaris Sportsman 800EFI & 800EFI service manual
2009 Polaris Sportsman 550XP service manual
2009 Polaris Sportsman 850XP service manual
2009 Polaris Trail Boss - Trailblazer 330 service manual
2010 Polaris Ranger RZR S service manual
2011 Polaris Ranger RZR S service manual
2011 Polaris Ranger RZR SW service manual
2012 Polaris Sportsman 400 service manual
Visit the Polaris service manual Section: https://www.quadcrazy.com/files/category/7-polaris-atv/
-
Recommended Posts
Join the conversation
You can post now and register later. If you have an account, sign in now to post with your account.
Note: Your post will require moderator approval before it will be visible.