Quantcast
Jump to content

Recommended Posts

Posted

Hello. I'm new to this forum. I just bought this big bear. This thing is show room condition. Now I haven't had time to dig into it so it might be easy to fix. But the guy I bought it from said it needs a CDI box. Now is there away to test these to see if it's bad? I see they are hard to find. Any recommendations on batteries? Any help would be greatly appreciated. I'll get back with results one I get time to look at it.

IMG_20180820_194137.jpg

  • Like 1
Posted

Well I tore it down and tried jumping it. It turned over for a second and then some buzzing/clicking came from the rear and briefly from the front. I would hate to by that CDI box not knowing if that's the problem. I see some relays in the rear. Just wondering the next steps to getting this thing running?

 

IMG_20180822_145732.jpg

IMG_20180822_150326.jpg

MVIMG_20180822_145759.jpg

Posted

Well I tore it down and tried jumping it. It turned over for a second and then some buzzing/clicking came from the rear and briefly from the front. I would hate to by that CDI box not knowing if that's the problem. I see some relays in the rear. Just wondering the next steps to getting this thing running?

 

  • Admin changed the title to 1987 Yamaha Big Bear How To Test CDI
Posted

Not necessarily, although that is not completely ruled out. What could be your issue is a lack of a full charge-12 volts or so- to everywhere it needs to go. If the solenoid is buzzing then there is something causing less power from getting through. Make sure your battery connections and other connections are tight and that all your grounds are good too. If a ground is corroded then sand it and see if that helps. Hope this helps.

  • Like 1
Posted

Yeah, get an extra set of hands to help and test voltage at the starter. I hope you get it figured out, I have a 2000 Big Bear I'm tearing down and trying to sort out. You know the old "it ran when I parked it" routine LOL

Posted

I just had this starting problem. The hot wire on the starter stud was deteriorated to rust powder. I replaced the starter and it cranks easily now. I too now have no spark. I am not saying the two are connected in any way. Just trying to help and learn...

  • 2 weeks later...
Posted

Hi there, I’ve got a 1990 Big Bear 350cc and was having trouble getting it going. I tried just about everything. I even bought a CDI unit. Well it turned out to be a faulty carburetor. I bought a single cable one and it works great. So…I’ve got an extra CDI unit that I’d like to sell. $150 Canadian + shipping 

I’ve also got a completely rebuilt dual cable carburetor that cost me $495 ca. I’d sell it for $300 Canadian 

( [email protected] )

I live in BC

Posted
Wasn't there a post a few years ago on a quick ignition test with an AA battery?
Saw it once, but cant find it now...

If someone could find the link to this i would like to check it out. Sounds very interesting.
Posted

If your Yamaha is cranking over fine but hasn't got spark, it's usually the stator. CDI modules rarely fail.

There are tests you can do with a multi meter on a stator but not on the module usually.

  • 4 weeks later...
Posted
On 9/5/2018 at 3:56 PM, bryanta0502 said:


If someone could find the link to this i would like to check it out. Sounds very interesting.

Any update on this? I'd be interested too.

Posted

Wow. Everyone is all over the place on this. 

Great looking bike awesome find lucky you! 

The cdi is a working or non working component.  So the fact that it fires up I would say it’s good.  

Now since you have all the plastics off and everything is exposed I would take your time and unplug each plug one at a time and clean and add electrical lube and reconnect. 

A good eye glass screwdriver allows you to get in and scrape clean the contacts of all the plugs.

after that go through all the wires that are attached with a bolt or screw, grounds, battery connectors and the starter relay .  It’s very possbale that the starter relay is no good and a much cheaper part to replace. Keep in mind the electrical system is big! That means the coil wires, ignition, handlebar controls, regulator etc. do it in sections and move on to the next section.

After all this is done if it still does the same thing it hasn’t cost a penny before you start guessing and buying parts and all bad connections are ruled out. 

Put a fresh battery in that baby and see what you got.

Lastly is I’ve had a bad cdi box and one way that it will not perform is if it has moisture inside. Simple stupid way to get that out is to put it in the oven for 10 min on 250! Make sure the oven is on 250 before you put it in and no more then 10 min. Take it out and cool off and try it. 

Good luck and keep up posted.

 

 

 

Join the conversation

You can post now and register later. If you have an account, sign in now to post with your account.
Note: Your post will require moderator approval before it will be visible.

Guest
Reply to this topic...

×   Pasted as rich text.   Paste as plain text instead

  Only 75 emoji are allowed.

×   Your link has been automatically embedded.   Display as a link instead

×   Your previous content has been restored.   Clear editor

×   You cannot paste images directly. Upload or insert images from URL.

  • Similar Forum Topics

    • By AnthonyT
      In search of my first ATV? What are good older 4x4 models?
    • By Thumpinhard25
      First thanks for any help guys, new to the forums and it's gotten me this far. I bought a 2001 bear tracker 250 for my family to get around the dirt bikes races. It wasn't running right and had a high idle. Previous owner thought it was a carb problem, so he ordered a new Zoom carb and new intake boot, but it still had the same high idle. ( I believe he had the throttle cable adjusted wrong, because it idled fine when I put it back together) So I tore down and cleaned the stock carb, and it started up and idled fine, but needed to have the choke 1/2 out to run.  I swapped to the new zoom carb and had the same issue. Choke half out bike ran ok. I played with the needle and the pilot screw with no change. ( bike did seem to be running rich though, but didn't get better when I tightened pilot screw or raised meddle) I Took it to the races and once I started bouncing around in the cattle fields the quad started cutting out real bad. It would barely run.  Sometimes it would run with choke off, sometimes choke 1/2, sometime choke full. I cleaned carb again, checked float level, and boots, no change still wouldn't run. Then suddenly it started running ok again.  This makes me believe it's an electrical issue rather then carb. I know there's no air leak, it's been checked, both carbs are clean( I've swapped them out a couple times, it starts up immediately and usually idles fine. But then bogs down/ or stutters under throttle. I saw the post on the guy who disconnected his rectifier and reconnected and suddenly it started working again, which lead me to believe it may be electrical and not carb.  So any advice on what I should check? Any way to test the CDI or rectifier?  Once again, I appreciate your help.  
    • By Mikey69
      Heres my story. Kinda long. I guess I was a late bloomer when it comes to quads. I had never ridden a quad in my life. Rode Dirt Bikes as a kid growing up. Back in Oct of '06 I found a Mustang on craigslist. Took it for a test drive one morning before work. Fast car. 351 Cleveland. I had planned on meeting the guy again after work. For some strange reason thats still to this day beyond me, I stopped in Hillsboro MotoSports on the way home from work. I had 6 Grand on me. There was a left over '05 sitting by the front door. It was on sale for $4999. It was $5499 OTD. I didnt even look at anything else. I knew nothing about quads accept I thought it really looked coool and I had the money in my pocket to buy it. I was sitting on it when the salesman walked up and asked... "Can I help you?" Without hestitation I pulled 60 Ben Franklins outta my front pocket and said "I want this Quad. Load it up in my truck." It was just about dark by the time I drove away from the shop. BTW, I didnt bother to ask my ol lady if I could buy it. LOL. Anyway, I took it by the house and showed her. She was kinda stunned but not mad. We drove over to a friend of mines house and unloaded it. I took it to the field across the street from his house. HOLY CHIT!!!!! I was surprised by the power. I had it for about 2 weeks and took it to Sand Lake. I was there a few hours and rolled it on a banked turn at the top of the bowl right before you get to the one-ways. When it rolled, I flew off and landed on my belly. The quad came bouncing and landed on my back. For a month I couldnt even walk. I was scared of it. I considered trading it for a 250EX. Went back to the shop. The salesman said..."Dude!!! You dont want a 250EX!!! Trust me. Just get used to it" I still wasnt convinced. I put it on craigslist for $4000. Calls were coming in. I had a guy that wanted to come look at it that evening. I decided to take it for one last ride at Browns Camp before I sold it. I was still afraid of it. After about 5 minutes I started feeling comfortable on it again. I decided right then, I loved my Honda 450 and would learn how to ride it instead of selling it. That was late Nov of '06. Work was slow for a Painter in Oregon. My new job everyday? Going to Browns Camp and ridding my Quad. I bought my Girl Friend an '02 Blaster. I rode my 450 for 4-6 hours almost every single day for 3 months. And yes, I know my way around Browns Camp pretty well. LOL. In March I bought her an '06 TRX250EX (Thank God I didnt trade my 450 for one of those) LOL Since then, I have become totally addicted to quads. I love them. Couldnt imagine not owning at least one quad. Luckily I have two. My "07 was $6500 OTD in July of '07. Bought it for my Girlfriend. Traded in her 250 EX. A month later we broke up. So, I wound up with two Honda 450's.
       
    • By kawasig
      Hello All
      I'm kinda new to ATVs. I just bought a 1987 Suzuki quad runner 230 Dual Range. I'm having a problem finding info on it. It's very clean, only 2.800 miles. The front wheels are only 30 in.center to center. I was thinking about adding wheel spacers to give it more stability. I realize the added stress on ball joints and bearings. I'm wondering if there are any other concerns? Any input is greatly appreciated!
    • By Kaz
      Troubleshooting a no spark issue, was running OK, maybe a little rich, turned it off, now no spark. I've checked/ohmed out the main key switch, the start/stop switch, neutral switch, brake switch - all good. It will crank the starter, but no spark with the starter or when I try the pull start. I've checked all fuses and diodes. Swapped battery. New plug. New coil. Swapped in a used CDI - no help. Traced, removed, cleaned, reattached all grounds. Removed things like my winch from the circuits to be sure a bad relay or something was dragging it down. When testing voltages, the orange wire going from the CDI to the ignition coil shows no/very low voltage-shouldn't it have 12V on it? Sometimes I get a very weak, intermittent glow on my spark tester, but not enough to fire the plug. I've checked continuity on just about all wires in the harness. Checked/cleaned/lubed w dielectric grease- all connections, redid a few that looked old/dirty. I've checked the stator resistances, all good, but have a stator and rectifier ordered anyway, will arrive Sunday. I verified that the rectifier has a voltage output back to charge the battery while cranking - 10.5-11V, low, but expected while starter is engaged. What else can I check as part of troubleshooting? I have a Haines service manual, but the 1999 350 4x4 seems to be an odd model, there isn't an exact electrical diagram for it, but found one for another year that has all the same number of wires and same color wires, so I've referenced that. Any hints, tips or advice would be appreciated! Thanks!
×
×
  • Create New...